How to Change Cabin Air Filter on Volvo XC60 XC90 V60 V90 S90 S60 (SPA), by VolvoDIYWorks on YouTube. 5 min 8 s.
- Video length
- 5 min 8 s
- Time to do it
- 15 minutes
- Difficulty
- Easy
- Steps
- 8
What you need
Steps
Park on a flat surface and switch off the ignition. Open the passenger door and look under the glovebox for the filter housing cover.
Release the cover. On most SPA models you undo a couple of Torx screws or press the clips, then lower the panel.
Pull the old filter straight out of the housing. Note which way the arrow on its edge points before you set it aside.
Wipe out any leaves or dust inside the housing with a clean cloth. Check the slot is clear before fitting the new filter.
Read the airflow arrow on the new filter. It should point toward the cabin, following the direction marked on the housing or the old filter.
Slide the new filter into the slot with the arrow facing the correct way. Push it in fully so it sits flat.
Refit the housing cover and tighten the screws or press the clips until they click. Make sure the cover sits flush.
Run the fan on each speed and check for rattles or weak airflow. A quick test confirms the filter and cover are seated right.
Tips and common mistakes
Match the arrow direction to the old filter or the marking on the housing, or airflow will drop.
Buy the filter by your exact model and year, since SPA housings can differ slightly.
Do the job every 15,000 to 20,000 miles or once a year if you drive in dusty areas.
Wear gloves if the old filter is dirty, and keep the car off while your hands are in the housing.
Questions
Which Volvo models does this fit?
It covers SPA platform cars such as the XC60, XC90, V60, V90, S60 and S90. Check your owner's manual or filter listing for your exact year.
How often should I replace the cabin air filter?
Most makers suggest every 15,000 to 20,000 miles or once a year. Change it sooner if the airflow smells musty or the fan feels weak.
Do I need special tools?
Usually just a Torx screwdriver or a plastic trim tool, depending on the model. A light helps you see the housing under the glovebox.
This guide was drafted from the video's details and general task knowledge. It has not been checked against the full video. Check the video and relevant product instructions before following a procedure. Report a correction.
